The Paddle dryer drain pump relies on the vacuum generated by the impeller to suck water up from below and then pump it up. If there is no water in the pump body, the vacuum cannot be formed, and the water cannot be sucked up. If the liquid level is higher than the pump, it can be used from The way of irrigation is to introduce water into the pump body, otherwise, irrigation is also required. Under normal circumstances, when the drain pump is working, if there is no liquid discharged from the dryer, the drain pump is working under no load, and it is normal that the noise is slightly louder than when the liquid is discharged. However, the noise will not be very large. The reasons for the abnormal noise when the drainage pump is working are: the deformation of the drainage pump fan blades and the collision and the abnormal noise; the drainage pump itself is damaged. At this time, it is necessary to take certain measures according to the specific situation to solve these problems. Therefore, we should check and repair the dryer in time during the process of using the dryer, and solve the problem immediately without delay, so as to extend the use cycle of the Paddle dryer.
There are reasons for accidents in the production of Paddle dryer. Before we find a solution, we should find the cause of the problem, so that we can not only find a quick cure, but also give our users and friends a suggestion. Just wake up and make everyone notice where this problem can occur. Next time you pay attention to daily inspections and maintenance, and pay more attention to reduce the frequency of failures, which can also save customers a lot of unexpected expenses.
